Overheat, coolant leak, limp mode, dealer

370zFORme!! · 08-09-2011, 07:17 PM

So I just got my car back about a week ago from the collision shop because I was involved in a small fender bender. My radiator support needed to be replaced and because of that, my insurance adjuster advised that all my coolant had to be removed and replaced.

Long story short, I was driving to Cerritos and as soon as I got off the freeway I smelled coolant. I immediately saw my water temps had shot up all the way to the last dot. I tried to pull over and my car starts to stutter, if that makes sense. SES light goes off and I could not rev past 1000 rpm (not that I even wanted to). Im assuming this is limp mode? I pulled over and let the car cool down some and looked under the car, noticing coolant leaking everywhere. Popped the hood, noticed the coolant tank was completely empty. Waited about 30 min, drove really slow with the heater on to the dealer and they are now looking into it. One of the techs advised that it seems like an air bubble caused the coolant to leak out of the tank through the overflow tube. He said these cars are designed to be able to drive in case of emergency with little to no water. Oil is different but water no problem.

My question is, could this have damaged my engine? I didn't really realize how far I was driving with high temps because nothing happened until I got off the freeway. I mean the SES light didn't even go off until the car went into limp mode. Could the guys that drained and refilled my coolant from the collision center not tightened something and thats what caused it? Im not really familiar with the cooling system on this car os I don't even know where else to start troubleshooting.

Sorry for the long post and thanks for any responses!

cossie1600 · 08-09-2011, 07:38 PM

Engine is probably okay if you didn't drive like that for too long. Loose upper radiator hose maybe?

Good luck dude

370zFORme!! · 08-09-2011, 07:42 PM

Thanks man, Im trying to stay positive and hoping this doesn't turn into one those reoccurring cooling issues or even worse one of those replacing engine issues.

cossie1600 · 08-09-2011, 08:15 PM

Modern engines are pretty tough, so your head gaskets are probably fine

christian370z · 08-09-2011, 09:08 PM

Cossie is right, your engine will be fine. Could you pin point the source of the leak? An air bubble in the water system could absolutely cause a temporary spike in coolant temperature but I am not sure about causing an overflow. Are all the coolant hoses securely sealed?

370zFORme!! · 08-09-2011, 09:32 PM

That's what I aim to find out. They are giving it a thorough inspection. I told them I wanted them to check every hose! Chris we still need to meet up man.

christian370z · 08-10-2011, 09:58 AM

Yes sir, I am getting back to Newport on Sunday so we will meet up next week for sure. I will let you know when I'm back!

370zFORme!! · 08-10-2011, 01:23 PM

Ah man, I'll be out of town for the next two weeks for work. Bad timing but I'll hit u up when I get back.

90 ST · 08-10-2011, 01:32 PM

Sounds like they didn't fill it up right, IIRC there is a air bleed in the system somewhere, sound slike they filled the rad and figured good to go.

370zFORme!! · 08-10-2011, 02:16 PM

Quote:

Originally Posted by 90 ST

Sounds like they didn't fill it up right, IIRC there is a air bleed in the system somewhere, sound slike they filled the rad and figured good to go.

Hmmm interesting thanks for the insight.

vividracing · 08-10-2011, 04:11 PM

I've never heard of a bubble causing a major leak. More than likely a house wasn't installed properly.

I had a coolant fitting pop out of my head on an old Civic after some hooning one night... Coolant completely leaked everywhere, temp was sky high... So I limped the car to my destination which was like 1/2 mile away and all was fine after I let it cool and refilled it w/ water. Drained water and refilled with coolant/distilled water as soon as I got home the next morning and the car ran great.

I'm sure your car is going to be fine.

370zFORme!! · 08-10-2011, 04:37 PM

Quote:

Originally Posted by vividracing

I've never heard of a bubble causing a major leak. More than likely a house wasn't installed properly.

I had a coolant fitting pop out of my head on an old Civic after some hooning one night... Coolant completely leaked everywhere, temp was sky high... So I limped the car to my destination which was like 1/2 mile away and all was fine after I let it cool and refilled it w/ water. Drained water and refilled with coolant/distilled water as soon as I got home the next morning and the car ran great.

I'm sure your car is going to be fine.

Thanks man this is good info!

vividracing · 08-10-2011, 06:14 PM

Quote:

Originally Posted by 370zFORme!!

Thanks man this is good info!

No problem. Another up side to my fitting exploding out of the head was that it was a great reason to spend the night at the chicks house. I think my car was a wing man.

And when I say the car was 100% fine after it happened, I mean it. It was an EG Civic w/ a mildly built B16 that had like 3500 miles when this happened. It was a weekend/toy car and pretty much stayed in the garage until I wanted to thrash it. I really beat the crap outta that engine and it loved every second of it. After I abused it for about 6 months, I traded it to a friend for a Jeep. He beat on it worse than I did, and at about 9k miles he blew the transmission up. The transmission was repaired and the car was sold to a 3rd owner who is still driving the car to this day afaik.

08-09-2011, 07:17 PM	#1 (permalink)
370zFORme!! Premium Member Join Date: Mar 2010 Location: SoCal Posts: 1,459 Drives: 2012 6MT STiffy Rep Power: 17	Overheat, coolant leak, limp mode, dealer So I just got my car back about a week ago from the collision shop because I was involved in a small fender bender. My radiator support needed to be replaced and because of that, my insurance adjuster advised that all my coolant had to be removed and replaced. Long story short, I was driving to Cerritos and as soon as I got off the freeway I smelled coolant. I immediately saw my water temps had shot up all the way to the last dot. I tried to pull over and my car starts to stutter, if that makes sense. SES light goes off and I could not rev past 1000 rpm (not that I even wanted to). Im assuming this is limp mode? I pulled over and let the car cool down some and looked under the car, noticing coolant leaking everywhere. Popped the hood, noticed the coolant tank was completely empty. Waited about 30 min, drove really slow with the heater on to the dealer and they are now looking into it. One of the techs advised that it seems like an air bubble caused the coolant to leak out of the tank through the overflow tube. He said these cars are designed to be able to drive in case of emergency with little to no water. Oil is different but water no problem. My question is, could this have damaged my engine? I didn't really realize how far I was driving with high temps because nothing happened until I got off the freeway. I mean the SES light didn't even go off until the car went into limp mode. Could the guys that drained and refilled my coolant from the collision center not tightened something and thats what caused it? Im not really familiar with the cooling system on this car os I don't even know where else to start troubleshooting. Sorry for the long post and thanks for any responses! __________________ 87' Honda Civic Hatchback: Kaput @ 288,000 miles, 90' Toyota Celica: Kaput @ 175,000 miles, 93' Mitsubishi 3000GT VR4: Kaput @ 138,000 miles, 06' Scion Tc: Traded in @ 64,000 miles, 10' Nissan 370z: Traded in @ 25,000 miles, 12' Subaru Impreza Sti: Current.

08-09-2011, 07:42 PM	#3 (permalink)
370zFORme!! Premium Member Join Date: Mar 2010 Location: SoCal Posts: 1,459 Drives: 2012 6MT STiffy Rep Power: 17	Thanks man, Im trying to stay positive and hoping this doesn't turn into one those reoccurring cooling issues or even worse one of those replacing engine issues. __________________ 87' Honda Civic Hatchback: Kaput @ 288,000 miles, 90' Toyota Celica: Kaput @ 175,000 miles, 93' Mitsubishi 3000GT VR4: Kaput @ 138,000 miles, 06' Scion Tc: Traded in @ 64,000 miles, 10' Nissan 370z: Traded in @ 25,000 miles, 12' Subaru Impreza Sti: Current.

08-09-2011, 09:08 PM	#5 (permalink)
christian370z A True Z Fanatic Join Date: Jul 2010 Location: Newport Beach Posts: 3,900 Drives: 2010 370Z/Saab 900se Rep Power: 431	Cossie is right, your engine will be fine. Could you pin point the source of the leak? An air bubble in the water system could absolutely cause a temporary spike in coolant temperature but I am not sure about causing an overflow. Are all the coolant hoses securely sealed? __________________ -320whp / 259wftlbs- SP Rays -- RE-11s -- SpecialtyZ Tune -- Swift Springs -- Stillen 25R Oil Cooler -- Stillen G3 Intakes -- Berk HFCs -- F.I. 12" CBE -- Stillen Sway Bars -- Es14 Spring -- INGS+1 lip -- CF Spoiler -- GTR Start Button -- VLED Parking Lights -- PWJDM V2 shift knob

08-09-2011, 09:32 PM	#6 (permalink)
370zFORme!! Premium Member Join Date: Mar 2010 Location: SoCal Posts: 1,459 Drives: 2012 6MT STiffy Rep Power: 17	That's what I aim to find out. They are giving it a thorough inspection. I told them I wanted them to check every hose! Chris we still need to meet up man. __________________ 87' Honda Civic Hatchback: Kaput @ 288,000 miles, 90' Toyota Celica: Kaput @ 175,000 miles, 93' Mitsubishi 3000GT VR4: Kaput @ 138,000 miles, 06' Scion Tc: Traded in @ 64,000 miles, 10' Nissan 370z: Traded in @ 25,000 miles, 12' Subaru Impreza Sti: Current.

08-10-2011, 09:58 AM	#7 (permalink)
christian370z A True Z Fanatic Join Date: Jul 2010 Location: Newport Beach Posts: 3,900 Drives: 2010 370Z/Saab 900se Rep Power: 431	Yes sir, I am getting back to Newport on Sunday so we will meet up next week for sure. I will let you know when I'm back! __________________ -320whp / 259wftlbs- SP Rays -- RE-11s -- SpecialtyZ Tune -- Swift Springs -- Stillen 25R Oil Cooler -- Stillen G3 Intakes -- Berk HFCs -- F.I. 12" CBE -- Stillen Sway Bars -- Es14 Spring -- INGS+1 lip -- CF Spoiler -- GTR Start Button -- VLED Parking Lights -- PWJDM V2 shift knob

08-09-2011, 07:38 PM	#2 (permalink)
cossie1600 A True Z Fanatic Join Date: Jun 2009 Location: californee way Posts: 5,380 Drives: 370, Leaf Rep Power: 29	Engine is probably okay if you didn't drive like that for too long. Loose upper radiator hose maybe? Good luck dude

08-09-2011, 08:15 PM	#4 (permalink)
cossie1600 A True Z Fanatic Join Date: Jun 2009 Location: californee way Posts: 5,380 Drives: 370, Leaf Rep Power: 29	Modern engines are pretty tough, so your head gaskets are probably fine

08-10-2011, 01:23 PM	#8 (permalink)
370zFORme!! Premium Member Join Date: Mar 2010 Location: SoCal Posts: 1,459 Drives: 2012 6MT STiffy Rep Power: 17	Ah man, I'll be out of town for the next two weeks for work. Bad timing but I'll hit u up when I get back. __________________ 87' Honda Civic Hatchback: Kaput @ 288,000 miles, 90' Toyota Celica: Kaput @ 175,000 miles, 93' Mitsubishi 3000GT VR4: Kaput @ 138,000 miles, 06' Scion Tc: Traded in @ 64,000 miles, 10' Nissan 370z: Traded in @ 25,000 miles, 12' Subaru Impreza Sti: Current.

08-10-2011, 01:32 PM	#9 (permalink)
90 ST A True Z Fanatic Join Date: May 2010 Location: Calgary Posts: 1,861 Drives: 90 and 15 GMC Sierra Rep Power: 420	Sounds like they didn't fill it up right, IIRC there is a air bleed in the system somewhere, sound slike they filled the rad and figured good to go.

08-10-2011, 04:11 PM	#11 (permalink)
vividracing The370Z.com Sponsor Join Date: Jun 2009 Location: Gilbert, AZ Age: 37 Posts: 7,306 Drives: 350Z,370Z,GTR Rep Power: 38	I've never heard of a bubble causing a major leak. More than likely a house wasn't installed properly. I had a coolant fitting pop out of my head on an old Civic after some hooning one night... Coolant completely leaked everywhere, temp was sky high... So I limped the car to my destination which was like 1/2 mile away and all was fine after I let it cool and refilled it w/ water. Drained water and refilled with coolant/distilled water as soon as I got home the next morning and the car ran great. I'm sure your car is going to be fine. __________________ Rocky @ Vivid ♦ 480.966.3040 x236 ♦ Rocky@vividracing.com Email, PM, or call me directly for aggressive The370Z.com member pricing!!!

Similar Threads
Thread	Thread Starter	Forum	Replies	Last Post
Unexplained Limp Mode	Dallas-Z	Engine & Drivetrain	77	08-22-2017 12:37 AM
Limp mode @ 3.5k rpm; no cel	zilent_jay	Nissan 370Z General Discussions	56	08-28-2012 09:44 AM
Limp mode troubles?	Bill Gephardt	New Forum Member	0	05-14-2010 06:15 PM
Possible limp mode?	DinoJ	Nissan 370Z General Discussions	21	09-04-2009 04:17 PM
Limp Mode Thresholds	spearfish25	Nissan 370Z General Discussions	8	05-09-2009 11:54 AM